Skip to main content
  • Research article
  • Open access
  • Published:

Screening the antifungal activity of essential oils against decay fungi from palmyrah leaf handicrafts

Abstract

Background

The whitish tender leaves of Palmyrah are used for making handicrafts. The problem with these articles is discolouration with time and become more brittle due to fungal attack. This could be prevented by some protective coating. Instead of expensive and harmful chemicals we decided to test natural plant essential oils to control fungal attack. Palmyrah leaf article decay fungi were isolated from two different sites of Jaffna peninsula. In this investigation Antifungal Activity of different plant essential oils from neem (Azadirachta indica), castor (Ricinus communis), citronella (Cymbopogon sp) and camphor (Cinnamomum camphora) obtained from local market have been evaluated against isolated fungi. For screening of Antifungal activity, tests and controls were set to determine minimum inhibitory concentration (MIC) and Percentage of Growth Inhibition.

Results

Morphologically three different types of Palmyrah leaf decay fungi were isolated and characterized as Aspergillus niger, Aspergillus flavus and Penicillium sp. Neem and castor oils have recorded no significant (0.05 > P) antifungal activity while citronella and camphor oils showed significantly different antifungal activity compared with control. Camphor oil and Citronella oil showed 100, 58.13% of average growth inhibition for A. niger. 96.38, 51.32% for A.flavus and 84.99, 72.76% for Penicillium sp respectively. Camphor oil showed highest percentage of growth inhibition at lowest minimum inhibitory concentration compared with citronella oil. Camphor oil was found to be highly antifungal and most effective against A niger, and A. flavus, compared with Penicillium sp and gave 100 percentage of growth inhibitions at 5, 1 and 15 ml/dl minimum inhibitory concentration respectively.

Conclusion

Significantly higher broad-spectrum of antifungal activity was observed in camphor oil than other tested oils because it showed highest percentage of growth inhibition at lowest inhibitory concentration. Therefore it could be used for the development of new environmental friendly antifungal agent for the preservation of leafy handicrafts. Further formulation, field experiments are necessary to achieve this target.

Background

Borassus flabellifer Linn (Palmyrah palm) these palm trees grow in a dry climate. The leaves of the palmyrah palm are thick, fibrous, initially strong and flexible, over time its flexibility decreases which is used to make handicrafts. They are also susceptible to insect attacks [1] and the lignified cells are particularly susceptible to degradation and discoloration. If not preserved properly they are subject to physical and fungal damage. Some of the most common deteriorating agents are climatic factors (e.g. variations in relative humidity and temperature) [1]. Agrawal [2] reported that conservation of palm leaf manuscripts using of citronella oil, camphor oil, or lemon grass oil on the surface of the leaf to keep it flexible. This prevents physical damage due to brittleness.

Essential oils are complex mixers comprising many single compounds. Chemically they are derived from terpenes and their oxygenated compounds. Each of these constituents has been shown to possess antibacterial, antifungal, antiviral insecticidal and antioxidant properties [3, 4]). The antimicrobial activity of different essential oils is known for many centuries. Large number of essential oils and their constituents were investigated for their antimicrobial properties against different bacteria and fungi strains [5, 6].Among the essential oils citronella oil has shown inhibitory effect on biodegrading and storage of contaminating fungi [7].

Fungi are significant destroyers not only of foodstuffs, grains but also in leaves during storage, unfit for human consumption by retarding their nutritive value and often by producing mycotoxins [8, 9]. A sizeable portion of the world population living below poverty line in the developing and underdeveloped countries of Asia and Africa are suffering from health problems associated with consuming mycotoxin contaminated grains and cereals [10]. Even though effective and efficient control of air borne fungi can be achieved by the use of synthetic chemical fungicides; the same cannot be applied to leaf for reasons of pesticide toxicity [1113] and durability of the leaf. Thus, there is a need to search for alternative approaches to store palmyrah leaf handicrafts without toxicity problems that are ecofriendly and cost effective.

Results and discussion

Isolation of palmyrah leaf article decay fungi

The palmyrah leaf is used for roofing, handicrafts and feed for livestock. The first two tender unexpanded whitish leaves and the next 12 young green leaves are used for making various handicrafts. The whitish tender leaves are used for making soft fine handicrafts while the young green leaves are used for making stronger, but coarse textured utility items like mats, baskets, packaging material, inner lining of heavy duty fibre baskets etc. The fungi affected palmyrah tender leaf articles were selected and using inoculation needle different colour colonies were inoculated into the PDA plate then incubated at room temperature for 4 days. After incubation black (B), green (G) and bluish green (A) colour of the colonies were observed. These three different colour colonies were selected for further study. Selected colonies were purified by repeated streaking. The purified fungi were maintained in agar slants at 4°C throughout the study and used as stock cultures.

Characterization of isolated fungal strains

Selected fungi B, G & A were identified as Aspergillus niger, Aspergillus flavus andPenicillium sp respectively at species level in based on macroscopic and microscopic features (Table 1).

Table 1 Macroscopic and microscopic features of isolated fungus

Antifungal activity assay

All species of fungi, using of any concentrations caused significant differences (p < 0.05) on inhibitory effect of essential oils. It could be seen that as essential oils concentrations increases the inhibitory effect increases (Figures 1, 2 and 3). In other words, the inhibitory effect of the essential oils was proportional to its concentration. This is in accordance with [14, 15]. Whereas increase in concentrations the susceptibility of fungi increases as well (Figure 4).

Figure 1
figure 1

Average growth inhibition of essential oils at different concentrations on Aspergillus flavus.

Figure 2
figure 2

Average growth inhibition of essential oils at different concentrations on Aspergillus niger.

Figure 3
figure 3

Average growth inhibition of essential oils at different concentrations on Penicilliumsp.

Figure 4
figure 4

Mycelial Growth inhibition of A.flavus at various concentration of camphor oil. Upper left -5 ml/dl, Upper right - 10 ml/dl, Lower left -15 ml/dl and Lower right -control which not contained oil.

Until now, there were no reports on the effects of essential oils on Palmyrah leaf decay fungi. Based on our findings, camphor oil affected the growth inhibition of the studied fungi. In all studied fungi, the essential oils caused significant differences (p < 0.05) on growth inhibition rates. In other words, the effects of growth inhibitory of plant essential oils depend on species of fungi [15].

The results showed that two plant essential oil such as citronella and camphor oil caused 100% of growth inhibition on all species of fungi at 25 ml/dl concentration while neem and castor oil not caused 100% of GI at same concentration. Therefore lower concentrations (10, 15 and 20 ml/dl) of each essential oils were used to determine the MIC on these fungi (Table 2). Camphor oil was the most effective essential oil on the A. niger, A. flavus and Peniillium with growth inhibition average of 100, 96.38 and 84.99% respectively. Whereas the citronella oil showed minor effect on A. niger, A. flavus and Peniillium with growth inhibition average of 58.13, 51.32 and 72.76% respectively.

Table 2 Growth inhibition (%) and MIC of essential oils

GI of A. niger was showed higher significant difference (p < 0.05) for citronella oil at 25 ml/dl and all the concentrations of camphor oil when compared with other oils similarly A. flavus showed higher significant difference (p < 0.05) for citronella oil at 25 ml/dl and camphor oil at 5, 10 and 15 ml/dl when compared with other oils while Penicillium showed higher significant difference (p < 0.05) only for 25 ml/dl of citronella and 15 ml/dl of camphor oil. Penicillium sp that isolated from palmyrah leaf was the most sensitive and most resistant to the studied essential oils.

Essential oils have two prominent features; low toxicity for people and environment due to their natural properties and low risk for resistance development by pathogenic microorganisms [16]. For these reasons and considering the results, we recommend the use of camphor oils for development of new and safe antifungal agent for the preservation of leafy handicrafts.

Conclusion

The results showed that citronella and camphor oils were very effective on Aspergillus niger,Aspergillus flavus and Penicillium sp. (palmyrah leaf article decay fungi)with growth inhibition average of 100% at 25 ml/dl concentration. Nevertheless, MIC of the essential oils was variable depending to species of fungi. Penicillium sp. was the most sensitive and most resistant to the camphor oil with 100% growth inhibition at 15 ml/dl concentration. Since growth inhibition of studied essential oils were evident in this study, they have potential to control of these palmyrah leaf article decay fungi and could be considered for developing new antifungal agent. Further field study need to be done to find out whether the use of this essential oil will prevent these fungal growth on leaf handicrafts after using this essential oil at cottage level handicraft industries in Sri Lanka.

Methods

Essential oils

The essential oils such as neem oil, castor oil, citronella oil and camphor oil, obtained from local market and exposed to UV radiation for 10 min then these oils were used for this study. These oils were selected based on literature survey and their use in preservation of leaf articles.

Isolation of palmyrah leaf decay fungi collection of sample

Palmyrah handicrafts are usually affected by fungus during rainy season. Affected tender leaf articles of Palmyrah were collected from two design centers of Palmyrah Development Board during rainy season and used for the isolation of Palmyrah leaf article decay fungus.

Preparation of potato dextrose agar media

PDA plates

Potato Dextrose Agar medium was prepared according to the manufacturer’s direction. After sterilization, the medium was allowed to cool to 50°C and poured in to sterile petridishes (20 mL/Petridish) under aseptic condition.

PDA slants

The PDA was prepared according to the manufacturer’s direction and 7 mL of the medium was poured into boiling tubes. The tubes were plugged with cotton wool and sterilized at 121°C and 15 lb/in2 for 15 min. The tubes were then cooled in an inclined position and used for storage of the fungus.

Isolation of fungal strains

Fungus affected leaf handicrafts were brought to laboratory and using inoculation needle different colour colonies were streaked on sterile PDA plates in Zig-Zag manner and incubated at room temperature for 3- 4 days. Selected colonies were purified by repeated streaking and transferred to PDA slants and kept at 4°C.

Characterization of isolated fungal strains

Selected fungal colonies were identified to species level based on macroscopic morphology and microscopic features.

Antifungal activity assay

PDA medium with 1, 15, 20 and 25 (ml/dl) concentrations of the essential oils such as neem, castor & citronella and 1, 5, 10 & 15 (ml/dl) of concentrations camphor oil were prepared. About 15 mL of the medium was poured into each petridish, Tween-20 (Sigma) was incorporated into the agar medium to enhance oil solubility and allowed to solidify. Nine mm disc of 5 days old culture of the test fungi from the margin of the plates were placed at the center of the petridishes and incubated at room temperature for 4 days. After incubation the colony diameter was measured in millimeter. For each treatment three replicates were maintained. PDA medium without the essential oil served as control. Growth zones were measured at 4th and 6 th days of incubation. The fungi toxicity of the oils in terms of percentage of growth inhibition of mycelia was calculated by using the formula:

Growthinhibition % =dcdt/dc×100

Where dc = Average increase in mycelial growth in control,

dt = Average increase in mycelial growth in treatment [17].

The antifungal agent nystatin added to the agar plates (final concentration of 1.0 mg/l) served as a positive control for Aspergillus niger, A. flavus and penicilliumsp.

Statistical analysis

MIC and percentage of inhibition were analysed by SAS package and the mean separation was done by LSD at p = 0.05.

References

  1. Udaya D, Kumar GV, Sreekumar U, Athvankar A: Traditional Writing System in Southern India - Palm Leaf Manuscripts. Southern India: Palm leaf manuscripts; 2009.

    Google Scholar 

  2. Agrawal and Om Prakesh: Conservation of Manuscripts and Paintings of South-east Asia. London: Butterworths& Co Ltd; 1984:43-48.

    Google Scholar 

  3. Burt SA: Essential oils: their antibacterial properties and potential applications in foods: a review. Inter J Food Microbiol 2004, 94: 223-253. 10.1016/j.ijfoodmicro.2004.03.022

    Article  CAS  Google Scholar 

  4. Kordali S, Kotan R, Mavi A, Cakir A, Ala A, Yildirim A: Determination of the chemical composition and antioxidant activity of the essential oil of artemisia dracunculus and of the antifungal and antibacterial activities of Turkish artemisia absinthium, a. Dracunculus, artemisia santonicum, and artemisia spicigera essential oils. J Agric Food Chem 2005, 53: 9452-9458. 10.1021/jf0516538

    Article  CAS  PubMed  Google Scholar 

  5. Bakkali F, Averbeck S, Averbeck D, Idaomar M: Biological effects of essential oils. A review. Food ChemToxicol 2008, 46: 446-475. 10.1016/j.fct.2007.09.106

    Article  CAS  Google Scholar 

  6. Kalemba D, Kunicka A: Antibacterial and antifungal properties of essential oils. Curr Med Chem 2003., 10(10):

  7. De Billerbeck VG, Roques CG, Bessiere JM, Fonvieille JL, Dargent R: Effects of cymbopogonnardus (L.) W. Watson essential oil on the growth and orphogenesis of aspergillusniger . Can J Microbiol 2001, 47: 9-17. 10.1139/cjm-47-1-9

    Article  CAS  PubMed  Google Scholar 

  8. Marin S, Homedes V, Sanchis V, Ramos AJ, Magan N: Impact of Fusariummoniliforme and F. proliferatum colonisation of maize on calorific losses and fumonisin production under different environmental conditions. J Stored Prod Res 1999, 35: 15-26. 10.1016/S0022-474X(98)00026-5

    Article  Google Scholar 

  9. Janardhana GR, Raveesha KA, Shetty HS: Modified atmosphere storage to prevent mould-induced nutritional loss in maize. J Sci Food Agri 1998, 76: 573-578. 10.1002/(SICI)1097-0010(199804)76:4<573::AID-JSFA991>3.0.CO;2-2

    Article  CAS  Google Scholar 

  10. Majumder UK, Gupta M, Mukhopadhyay DK: Effect of mycotoxins isolated from Penicilliumnigricans on glucose-6-phosphate dehydrogenase. Indian J Exp Biol 1997, 35: 1233-1236.

    CAS  PubMed  Google Scholar 

  11. Ferrer A, Cabral R: Toxic epidemics caused by alimentary exposure to pesticides: a review. Food Additives Contamin 1991, 8: 755-776. 10.1080/02652039109374034

    Article  CAS  Google Scholar 

  12. Harris CA, Renfrew MJ, Woolridge MW: Assessing the risk of pesticide residues to consumers: recent and future developments. Food additives Contaminat 2001, 18: 1124-1129. 10.1080/02652030110050122

    Article  CAS  Google Scholar 

  13. Dukic NM, Bozin B, Sokovic M, Simin N: Antimicrobial and antioxidant activity of melissa officinalisL. (lamiaceae) essential oil. J Agri Food Chem 2004, 52: 2485-2489. 10.1021/jf030698a

    Article  Google Scholar 

  14. Rasooli I, Rezaei MB, Allameh A: A. Growth inhibition and morphological alterations of aspergillusniger by essential oils from thymus eriocalyx and thymus xporlock . Food Control 2006, 17: 359-364. 10.1016/j.foodcont.2004.12.002

    Article  CAS  Google Scholar 

  15. Amini M, Safaie N, Salmani MJ, And Shams-Bakhsh M: Antifungal activity of three medicinal plant essential oils against some phytopathogenic fungi. Trakia J Sci 2012, 10: 1-8.

    Google Scholar 

  16. Daferera DJ, Ziogas BN, Polissiou MG: GC-MS analysis of essential oils from some greek aromatic plants and their fungitoxicity on Penicilliumdigitatum . J Agric Food Chem 2000, 48: 2576-2581. 10.1021/jf990835x

    Article  CAS  PubMed  Google Scholar 

  17. Singh J, Tripathi NN: Inhibition of storage fungi of blackgram ( Vignamungo ) by some essential oils. Flavour Fragr J 1999, 14: 1-4. 10.1002/(SICI)1099-1026(199901/02)14:1<1::AID-FFJ735>3.0.CO;2-R

    Article  CAS  Google Scholar 

Download references

Acknowledgements

The authors thank Ministry of traditional industries and small enterprise development, Sri Lanka for financial support.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Jeyarani Nandakumar.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors’ contribution

JN- supervised the research project SM, JN&RK carriedout the antimicrobial activity study; participated in isolation of fungus from Palmyrah handicrafts. JN&SM- Drafted the manuscript. NAM- carriedout statistical analysis. SSV- coordinated & management of research activities. All authors read and approved the final manuscript.

Authors’ original submitted files for images

Rights and permissions

Open Access  This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made.

The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder.

To view a copy of this licence, visit https://creativecommons.org/licenses/by/4.0/.

The Creative Commons Public Domain Dedication waiver (https://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Mahilrajan, S., Nandakumar, J., Kailayalingam, R. et al. Screening the antifungal activity of essential oils against decay fungi from palmyrah leaf handicrafts. biol res 47, 35 (2014). https://doi.org/10.1186/0717-6287-47-35

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/0717-6287-47-35

Keywords